Home › Makes › Chevrolet › Tahoe › 2003
2003 Chevrolet Tahoe recalls
NHTSA has 4 safety recall campaigns on record for the 2003 Chevrolet Tahoe. Decode your VIN to confirm the exact vehicle.
Recall list
Seat belts:rear/other
NHTSA 05V163000April 22, 20051,359,824 units
Problem: On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Risk: A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Remedy: Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Service brakes, hydraulic
NHTSA 04V045000February 4, 200468,875 units
Problem: Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Risk: Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Remedy: Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Structure
NHTSA 03V094000March 7, 20033,674 units
Problem: Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Risk: This overheating condition can cause the running board to melt or cause a fire.
Remedy: Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Structure:body:door:hinge and attachments
NHTSA 03V037000February 6, 2003107 units
Problem: Certain sport utility vehicles fail to comply with requirements of federal motor vehicle safety standard no. 214, "side impact protection." these vehicles are built with four welds on the rear door upper hinge. On some of these vehicles, one or two of the welds may not be to specification.
Risk: As a result, the door strength may be degraded during a side impact vehicle crash.
Remedy: Dealers will inspect the welds on the left rear door upper hinge. If a weld is found out-of-specification, a bolt will be installed to secure the hinge. Owner notification began february 17, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cadillac at 1-800-458-8006, chevrolet at 1-800-222-1020, or gmc at 1-800-462-8782.
Source: NHTSA recall database. A recall applies to vehicles built in a specific date range; check your VIN at nhtsa.gov/recalls.
Questions
How many recalls does the 2003 Chevrolet Tahoe have?
NHTSA records list 4 safety recall campaigns for the 2003 Chevrolet Tahoe.
How do I know if my 2003 Chevrolet Tahoe has an open recall?
Enter your VIN on NHTSA.gov's recall lookup (nhtsa.gov/recalls). It shows unrepaired recalls for your exact vehicle. Recall repairs are free at authorized dealers.